[Date Prev][Date Next][Thread Prev][Thread Next][Date Index][Thread Index]

RE: [TCML] Stranded/silver plated wire (was Scientific Method)



I have no scientific information but I did run out and check my roll of
"silver" wire.
0.050 OD
0.0065 covering
0.037 stripped ( hard red "plastic' insulation)
19 strands of 0.0085 wire
It was obtained from a surplus store.

Rich , KDØZZ
Disclaimer: Any errors in spelling or facts are transmission errors.




-----Original Message-----
From: tesla-bounces@xxxxxxxxxx [mailto:tesla-bounces@xxxxxxxxxx] On Behalf
Of DC Cox
Sent: Wednesday, July 29, 2009 8:34 AM
To: Tesla Coil Mailing List
Subject: Re: [TCML] Stranded/silver plated wire (was Scientific Method)

I use the 19 strand silver tinned type wire usually in 14 to 18 AWG on many
of my high power coils.  The 7 strand is not adequate.

Dr. Resonance




On Tue, Jul 28, 2009 at 8:44 PM, jimlux <jimlux@xxxxxxxxxxxxx> wrote:

> Lau, Gary wrote:
>
>> Are you saying that you use silver-plated STRANDED wire for
>> secondaries?  Granted, AC resistance and Q are far less important on
>> the secondary side, but the notion of this wire being superior to
>> common magnet wire is incorrect.  Stranded wire is inherently more
>> lossy at RF frequencies.  This is because the skin effect causes
>> current to travel on the outer surface of the bundle.  If a strand on
>> the outside of the bundle weaves to the interior of the bundle, the
>> current in that strand will try to find its way back to the surface,
>> and this means traveling to adjacent conductors, through any
>> resistive oxide layers between them.  This strand-hopping results in
>> a much higher AC resistance than if a single conductor were used.
>> This is the reason that Litz wire insulates the strands from one
>> another.
>>
>
> Most stranded wire is NOT braided. It's something like 7 strands, so the
>  outside strands stay outside. THe other thing is that 100kHz-ish
> frequencies have a fairly thick skin depth (0.2 mm in copper). It's not
like
> at 15 MHz where skin depth is a few tens of microns.
>
>
>
>
>
>> _______________________________________________
> Tesla mailing list
> Tesla@xxxxxxxxxxxxxx
> http://www.pupman.com/mailman/listinfo/tesla
>
_______________________________________________
Tesla mailing list
Tesla@xxxxxxxxxxxxxx
http://www.pupman.com/mailman/listinfo/tesla
No virus found in this incoming message.
Checked by AVG - www.avg.com 
Version: 8.5.392 / Virus Database: 270.13.34/2268 - Release Date: 07/29/09
06:12:00

_______________________________________________
Tesla mailing list
Tesla@xxxxxxxxxxxxxx
http://www.pupman.com/mailman/listinfo/tesla